XLPE电缆绝缘热老化的高压频域介电谱诊断方法

doi:10.19595/j.cnki.1000-6753.tces.210962

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (2197 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要热老化是导致XLPE电缆绝缘性能下降的重要原因,实现热老化的诊断对电缆安全具有重要意义,为此该文对XLPE电缆整体和局部热老化高压频域介电谱特性进行研究。通过内外加热法制备了整体热老化电缆试样和用于模拟局部热老化电缆线段,分别在不同老化阶段检测了整体热老化、局部热老化段与完好电缆比值为10%、4%的10kV缺陷电缆的高压频域介电谱（0.01~0.1Hz,最高检测电压U₀）,分析了局部老化段占比对介电常数的影响,定义并分析了曲线分层度L、斜率、曲线积分和非线性度η。研究结果表明：高压频域介电谱对整体、局部热老化反应灵敏;具有一定老化程度的整体热老化、局部热老化缺陷电缆试样的L均大于1,L矩阵可作为电缆老化现象的诊断参数;较高检测电压等级（1.0U₀）介电谱曲线的η对老化程度的变化敏感,且受局部缺陷占比影响较小,可以作为电缆老化程度的诊断特征;局部老化段的占比减小会使高压频域介电谱出现分层对应的时间延后,介电谱曲线积分值、曲线斜率减小,可以结合η的数值及曲线积分、斜率值所在数值区间判定电缆是否为局部老化;介电谱曲线是否出现迟滞现象可以作为区分XLPE电缆热老化和水树老化的依据。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	王昊月
	王晓威
	孙茂伦
	王伟
	李成榕

关键词 ： XLPE电缆, 热老化, 高压频域介电谱, 诊断

Abstract：Thermal aging is the important reasons for the degradation of XLPE cable insulation. The timely detection and treatment are of great significance for system operation safety. The research on diagnosis of XLPE cable overall and local aging using high voltage frequency domain spectroscopy (FDS) is carried out. The high voltage FDS (0.01Hz~0.1Hz, detection voltage up to U₀) of 10 kV cables with overall length, with ratio of local thermal aging section to intact cable of 10% and 4% at different thermal aging stages are measured. Besides, the layering degree of the high voltage FDS curves L, slope and integral, and nonlinearity η are defined and analyzed. The effects of local aging ratio on the dielectric parameters are also studied. The results show that high voltage FDS is sensitive to both overall and local thermal aging, The L parameters of cable samples with overall and local thermal aging defects with a certain degree are greater than 1, so L matrix can be used as the diagnostic parameter of cable aging. Nonlinearity η is sensitive to the change of aging degree, and it is less affected by the proportion of local defects, so it can be used as a diagnostic characteristic of cable aging degree. With the decrease of the aging section proportion, the curves show layered characteristics later, and the integral value of dielectric spectrum curve and the slope of the curve are reduced. It can be determined whether the cable is thermal aged by combining the value of η and the range of slope and integral. The hysteresis phenomenon can be used as basis to distinguish thermal aging and water tree aging of XLPE cable.

Key words： XLPE cable thermal aging high voltage frequency domain spectroscopy diagnosis

收稿日期: 2021-06-23

PACS:

TM85

通讯作者: 王伟男,1979年生,副教授,研究方向为电气设备在线监测与诊断等。E-mail：ww790324@163.com

作者简介: 王昊月女,1993年生,博士研究生,研究方向为电力电缆故障检测及评估。E-mail：ncepu_why@ncepu.edu.cn

引用本文:

王昊月, 王晓威, 孙茂伦, 王伟, 李成榕. XLPE电缆绝缘热老化的高压频域介电谱诊断方法[J]. 电工技术学报, 2022, 37(17): 4497-4507. Wang Haoyue, Wang Xiaowei, Sun Maolun, Wang Wei, Li Chengrong. High Voltage Frequency Domain Dielectric Spectroscopy Diagnosis Method for Thermal Aging of XPLE Cables. Transactions of China Electrotechnical Society, 2022, 37(17): 4497-4507.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.210962 https://dgjsxb.ces-transaction.com/CN/Y2022/V37/I17/4497

[1] 邓雯玲, 卢继平, 苟鑫, 等. 适用于高压电缆-架空线混合线路的新型重合闸方案[J]. 电力系统自动化, 2021, 45(12): 126-132.
Deng Wenling, Lu Jiping, Gou Xin, et al.Novel reclosing scheme for hybird lines with high-voltage cable and overhead lines[J]. Automation of Electric Power Systems, 2021, 45(12): 126-132.
[2] 王孟夏, 周生远, 杨明, 等. 计及海底电缆热特性的可接纳海上风电装机容量评估方法[J]. 电力系统自动化, 2021, 45(6): 195-202.
Wang Mengxia, Zhou Shengyuan, Yang Ming, et al.Assessment method for acceptable installed capacity of offshore wind farms considering thermal characteristics of submarine cables[J]. Automation of Electric Power Systems, 2021, 45(6): 195-202.
[3] 朱煜峰, 许永鹏, 陈孝信, 等. 基于卷积神经网络的直流XLPE电缆局部放电模式识别技术[J]. 电工技术学报, 2020, 35(3): 659-668.
Zhu Yufeng, Xu Yongpeng, Chen Xiaoxin, et al.Pattern recognition of partial discharges in DC XLPE cables based on convolutional neural network[J]. Transactions of China Electrotechnical Society, 2020, 35(3): 659-668.
[4] 周凯, 李诗雨, 尹游, 等. 退运中压XLPE和EPR电缆老化特性分析[J]. 电工技术学报, 2020, 35(24): 5197-5206.
Zhou Kai, Li Shiyu, Yin You, et al.Analysis of aging characteristics of medium voltage XLPE and EPR retired cables[J]. Transactions of China Electrotechnical Society, 2020, 35(24): 5197-5206.
[5] Nobrega A M, Martinez M L B, de Queiroz A A A. Investigation and analysis of electrical aging of XLPE insulation for medium voltage covered conductors manufactured in Brazil[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2013, 20(2): 628-640.
[6] Ouyang Benhong, Li Huan, Zhang Xu, et al.The role of micro-structure changes on space charge distribution of XLPE during thermo-oxidative ageing[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2017, 24(6): 3849-3859.
[7] Liu Yunpeng, Liu Hechen, Yu Lichao, et al.Effect of thermal stress on the space charge distribution of 160 kV HVDC cable insulation material[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2017, 24(3): 1355-1364.
[8] Kemari Y, Mekhaldi A, Teyssèdre G, et al.Correlations between structural changes and dielectric behavior of thermally aged XLPE[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2019, 26(6): 1859-1866.
[9] 陈曦, 骆高超, 曹杰, 等. 基于改进K-近邻算法的XLPE电缆气隙放电发展阶段识别[J]. 电工技术学报, 2020, 35(23): 5015-5024.
Chen Xi, Luo Gaochao, Cao Jie, et al.Development stage identification of XLPE cable air-gap discharge based on improved K-nearest neighbor algorithm[J]. Transactions of China Electrotechnical Society, 2020, 35(23): 5015-5024.
[10] 尹游, 周凯, 李诗雨, 等. 基于极化去极化电流法的水树老化XLPE电缆界面极化特性分析[J]. 电工技术学报, 2020, 35(12): 2643-2651.
Yin You, Zhou Kai, Li Shiyu, et al.Interface polarization characteristics of water tree aged XLPE cables based on polarization and depolarization current method[J]. Transactions of China Electrotechnical Society, 2020, 35(12): 2643-2651.
[11] Al-Arainy A, Malik N H, Qureshi M I, et al.The performance of strippable and bonded screened medium-voltage XLPE-insulated cables under long-term accelerated aging[J]. IEEE Transactions on Power Delivery, 2007, 22(2): 744-751.
[12] 谢声益, 杨帆, 黄鑫, 等. 基于太赫兹时域光谱技术的交联聚乙烯电缆绝缘层气隙检测分析[J]. 电工技术学报, 2020, 35(12): 2698-2707.
Xie Shengyi, Yang Fan, Huang Xin, et al.Air gap detection and analysis of XLPE cable insulation based on terahertz time domain spectroscopy[J]. Transactions of China Electrotechnical Society, 2020, 35(12): 2698-2707.
[13] 周利军, 王媚, 周韫捷, 等. 介电谱用于评估XLPE电缆绝缘劣化状态的研究[J]. 绝缘材料, 2019, 52(1): 52-56.
Zhou Lijun, Wang Mei, Zhou Yunjie, et al.Deterioration condition evaluation of XLPE cable insulation by dielectric spectroscopy[J]. Insulating Materials, 2019, 52(1): 52-56.
[14] Werelius P.Development and application of high voltage dielectric spectroscopy for diagnosis of medium voltage XLPE cables[D]. Stockholm: Royal Institute of Technology(KTH), 2001.
[15] Werelius P, Tharning P, Eriksson R, et al.Dielectric spectroscopy for diagnosis of water tree deterioration in XLPE cables[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2001, 8(1): 27-42.
[16] Pedersen K, Sedding H, Fenger M, et al.Laboratory results from dielectric spectroscopy of field aged XLPE cables with respect to water trees[C]// Conference Record of the 2006 IEEE International Symposium on Electrical Insulation, Toronto, ON, Canada, 2006: 509-514.
[17] JWG D1/B1.20-493 493 Non-destructive water-Tree detection in XLPE cable insulation [R]. CIGRE, 2012.
[18] 国家质量监督检验检疫总局, 中国国家标准化管理委员会. 额定电压1kV(Um=1.2kV)到35kV(Um= 40.5kV)挤包绝缘电力电缆及附件第2部分:额定电压6kV(Um=7.2kV)到30kV: GB/T 12706.2—2020[S]. 北京: 中国标准出版社, 2021.
[19] 国家质量监督检验检疫总局. 电气绝缘材料耐热性第1部分:老化程序和试验结果的评定: GB/T 11026.1—2016[S]. 北京: 中国标准出版社, 2017.
[20] 李康乐, 周凯, 张桥峰, 等. 水树生长中XLPE晶区破坏现象及其对水树生长速率的影响[J]. 高电压技术, 2021, 47(11): 4095-4103.
Li Kangle, Zhou Kai, Zhang Qiaofeng, et al.Phenomenon of XLPE crystalline region damage in water tree propagation and its influence on propagation rate of water trees[J]. High Voltage Engineering, 2021, 47(11): 4095-4103.
[21] Guide for Field Testing of Shielded Power Cable Systems Using Very Low Frequency (VLF) (Less than 1 Hz): IEEE 400.2: 2013 than 1 Hz): IEEE 400.2: 2013[S]. Institute of Electrical & Electronics Engineers, 2013.
[22] 方俊鑫, 殷之文. 电介质物理学[M]. 北京: 科学出版社, 1989.
[23] Perkel J, Del Valle Y, Hampton R N, et al.Interpretation of dielectric loss data on service aged polyethylene based power cable systems using VLF test methods[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2013, 20(5): 1699-1711.
[24] Zaengl W S.Dielectric spectroscopy in time and frequency domain for HV power equipment. I. theoretical considerations[J]. IEEE Electrical Insulation Magazine, 2003, 19(5): 5-19.
[25] Hvidsten S, Ildstad E, Sletbak J, et al.Understanding water treeing mechanisms in the development of diagnostic test methods[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 1998, 5(5): 754-760.
[26] 赵威, 周凯, 刘凡, 等. 在XLPE电缆加速老化过程中理解水树的自愈性[J]. 电工技术学报, 2014, 29(6): 311-317, 332.
Zhao Wei, Zhou Kai, Liu Fan, et al.Understanding self-healing of water tree in process of accelerated aging of XLPE cables[J]. Transactions of China Electrotechnical Society, 2014, 29(6): 311-317, 332.
[27] Zaengl W S.Applications of dielectric spectroscopy in time and frequency domain for HV power equipment[J]. IEEE Electrical Insulation Magazine, 2003, 19(6): 9-22.