Suppression Strategies of Electromagnetic Switch High-Frequency Holding Noise
Tang Longfei1,2, Zhuang Jianxiong1, Sun Huaiyi1, Xu Zhihong1,2
1. School of Electrical Engineering and Automation Fuzhou University Fuzhou 350108 China; 2. Fujian Key Laboratory of New Energy Generation and Power Conversion Fuzhou 350108 China
Abstract：The problem of high-frequency holding noise caused by electromagnetic switch under PWM closed-loop control is studied, and an adaptive control strategy for electromagnetic switch high-frequency holding noise is proposed in this paper. Firstly, the mechanism of electromagnetic switch high-frequency closed-loop noise is analyzed, and three measures are proposed to suppress the high-frequency noise. Secondly, according to the actual operation characteristics of electromagnetic switch, an adaptive suppression strategy of electromagnetic switch high-frequency holding noise based on fuzzy control is designed. By integrating the advantages of on/off control, self-tuning PID control and pseudo open-loop control, the noise suppression measures are implemented. Finally, the electromagnetic switch co-simulation model is constructed, and the rapid control prototype verification system of electromagnetic switch based on CompactRIO is developed. The frequency domain analysis of electromagnetic switch noise and vibration signal is carried out, and the control strategy is verified. Simulation and experimental results show that the proposed control strategy can effectively suppress the high-frequency holding noise of electromagnetic switch.
[1] 许志红. 电器理论基础[M]. 北京: 机械工业出版社, 2014. [2] 张立. 低压电器设备智能化发展探析[J]. 电气技术, 2017, 18(6): 104-110. Zhang Li.Discussion on intelligent development of low voltage electrical equipment[J]. Electrical Engineering, 2017, 18(6): 104-110. [3] 张培铭. 智能低压电器技术研究[J]. 电器与能效管理技术, 2019(15): 10-20. Zhang Peiming.Research on technology of intelligent low voltage electrical apparatus[J]. Electrical & Energy Management Technology, 2019(15): 10-20. [4] 刘建强, 刘传铎, 王轶欧, 等. 单相PWM整流器IGBT及直流侧电容故障诊断方法[J]. 电工技术学报, 2019, 34(增刊1): 244-257. Liu Jianqiang, Liu Chuanduo, Wang Yiou, et al.Fault diagnosis method for IGBT and DC-link capacitor of single-phase PWM rectifier[J]. Transactions of China Electrotechnical Society, 2019, 34(S1): 244-257. [5] 纽春萍, 陈德桂, 李兴文, 等. 交流接触器触头弹跳的仿真及影响因素[J]. 电工技术学报, 2007, 22(10): 85-90. Niu Chunping, Chen Degui, Li Xingwen, et al.Simulation of contact bounce of AC contactor and study of its influence factors[J]. Transactions of China Electrotechnical Society, 2007, 22(10): 85-90. [6] Liu Yingyi, Chen Degui, Ji Liang, et al.Dynamic characteristic and contact bounce analysis for an AC contactor with PWM controlled coil[C]//Electrical Contacts-2007 Proceedings of the 53rd IEEE Holm Conference on Electrical Contacts, Pittsburgh, PA, 2007: 289-293. [7] 庄杰榕, 许志红. 智能接触器准临界电流搜索自起动控制[J]. 电机与控制学报, 2019, 23(6): 73-80. Zhuang Jierong, Xu Zhihong.Self-starting control with quasi-critical current search for intelligent contactor[J]. Electric Machines and Control, 2019, 23(6): 73-80. [8] Dulk I, Kovacshazy T.Modelling of a linear proportional electromagnetic actuator and possibi- lities of sensorless plunger position estimation[C]// 2011 12th Carpathian Control Conference (ICCC), Czech Republic, 2011: 89-93. [9] 房淑华, 林鹤云, 蔡彬, 等. 永磁接触器合闸过程的动态仿真及实验[J]. 电工技术学报, 2007, 22(2): 45-50. Fang Shuhua, Lin Heyun, Cai Bin, et al.Dynamic simulation and experiment for making process of permanent magnet contactor[J]. Transactions of China Electrotechnical Society, 2007, 22(2): 45-50. [10] 汪先兵, 林鹤云, 房淑华, 等. 永磁接触器位移分段PWM控制及吸合过程动态特性分析[J]. 中国电机工程学报, 2010, 30(3): 113-118. Wang Xianbing, Lin Heyun, Fang Shuhua, et al.Analysis of displacement subsection PWM control and dynamic characteristic for closing process of permanent magnet contactor[J]. Proceedings of the CSEE, 2010, 30(3): 113-118. [11] 汤龙飞, 许志红. 交流接触器斜率闭环控制技术[J]. 中国电机工程学报, 2017, 37(3): 956-965. Tang Longfei, Xu Zhihong.The slope closed-loop control technology of the AC contactor[J]. Pro- ceedings of the CSEE, 2017, 37(3): 956-965. [12] 李晓华, 赵容健, 田晓彤, 等. 逆变器供电对电动汽车内置式永磁同步电机振动噪声特性影响研究[J]. 电工技术学报, 2020, 35(21): 4455-4464. Li Xiaohua, Zhao Rongjian, Tian Xiaotong, et al.Study on vibration and noise characteristics of interior permanent magnet synchronous machine for electric vehicles by inverter[J]. Transactions of China Electrotechnical Society, 2020, 35(21): 4455-4464. [13] 潘超, 衣双园, 蔡国伟, 等. 交直流混杂模式下变压器励磁-振动特性研究[J]. 电工技术学报, 2019, 34(18): 3788-3796. Pan Chao, Yi Shuangyuan, Cai Guowei, et al.Excitation-vibration characteristics of transformer in AC-DC hybrid operation[J]. Transactions of China Electrotechnical Society, 2019, 34(18): 3788-3796. [14] 曹辰, 林莘, 金鑫, 等. 基于有限元方法的变压器绕组振动多物理场仿真研究[J]. 变压器, 2018, 55(3): 21-26. Cao Chen, Lin Xin, Jin Xin, et al.Research on multiphysics simulation of transformer winding vibration based on finite element method[J]. Trans- former, 2018, 55(3): 21-26. [15] 汲胜昌, 祝令瑜, 沈琪, 等. 换流站用交流滤波电容器的噪声试验与仿真[J]. 高电压技术, 2011, 37(12): 2897-2903. Ji Shengchang, Zhu Lingyu, Shen Qi, et al.Experi- ment and simulation of audible noise for AC filter capacitor used in converter station[J]. High Voltage Engineering, 2011, 37(12): 2897-2903. [16] 祝令瑜, 汲胜昌, 曹涛, 等. 电容器噪声传播规律的研究[J]. 电力电容器与无功补偿, 2013, 34(6): 50-55. Zhu Lingyu, Ji Shengchang, Cao Tao, et al.Study on propagation law of capacitor audible noise[J]. Power Capacitor & Reactive Power Compensation, 2013, 34(6): 50-55. [17] 师愉航, 李金宇, 汲胜昌, 等. 交流滤波电容器振动噪声特性及声场控制研究[J]. 电力电容器与无功补偿, 2017, 38(1): 65-70. Shi Yuhang, Li Jinyu, Ji Shengchang, et al.Study on vibration and noise characteristics of AC filter capacitor and acoustic field control[J]. Power Capacitor & Reactive Power Compensation, 2017, 38(1): 65-70. [18] 刘和平, 刘庆, 张威, 等. 电动汽车用感应电机削弱振动和噪声的随机PWM控制策略[J]. 电工技术学报, 2019, 34(7): 1488-1495. Liu Heping, Liu Qing, Zhang Wei, et al.Random PWM technique for acoustic noise and vibration reduction in induction motors used by electric vehicles[J]. Transactions of China Electrotechnical Society, 2019, 34(7): 1488-1495. [19] 陈首虹, 杨建红, 范伟, 等. 交流接触器振动噪声测量方法及系统开发[J]. 华侨大学学报 (自然科学版), 2019, 40(4): 429-436. Chen Shouhong, Yang Jianhong, Fan Wei, et al.Vibration and noise measurement method of AC contactor and system development[J]. Journal of Huaqiao University (Natural Science), 2019, 40(4): 429-436. [20] 赵建, 鲍光海. 交流接触器振动噪声故障在线检测[J]. 电器与能效管理技术, 2018(18): 53-57. Zhao Jian, Bao Guanghai.On-line detection of AC contactor based on vibration and noise fault[J]. Electrical & Energy Management Technology, 2018(18): 53-57. [21] 张雄清, 林毅, 戴涛. 电磁式接触器智能控制模块设计及试验[J]. 电气技术, 2011, 12(2): 44-46. Zhang Xiongqing, Lin Yi, Dai Tao.The design of electromagnetic contact with intelligent control module[J]. Electrical Engineering, 2011, 12(2): 44-46. [22] 庄杰榕, 许志红. 电磁接触器多变量反馈吸持控制策略的研究[J]. 中国电机工程学报, 2019, 39(5): 1516-1526. Zhuang Jierong, Xu Zhihong.The multivariate feedback control strategy for electromagnetic contactor holding[J]. Proceedings of the CSEE, 2019, 39(5): 1516-1526. [23] 庄杰榕, 许志红. 智能电磁接触器自抗扰电流模型预测控制[J]. 电工技术学报, 2018, 33(23): 5449-5458. Zhuang Jierong, Xu Zhihong.The active disturbance rejection with current model predictive control for intelligent electromagnetic contactor[J]. Transactions of China Electrotechnical Society, 2018, 33(23): 5449-5458. [24] Tang Longfei, Han Zhiping, Xu Zhihong.Neural network-based co-simulation technology for intel- ligent contactors[J]. IEEE Transactions on Magnetics, 2020, 56(2): 8000108. [25] Tang Longfei, Xu Zhihong, Venkatesh B.Contactor modeling technology based on an artificial neural network[J]. IEEE Transactions on Magnetics, 2018, 54(2): 4900108. [26] Barrera E, Ruiz M, Bustos A, et al.Implementation of ITER fast plant interlock system using FPGAs with CompactRIO[J]//IEEE Transactions on Nuclear Science, 2018, 65(2): 796-804. [27] Bourhnane S, Lghoul R, Zine-Dine K, et al.Real-time control of smart grids using NI CompactRIO[C]//2019 International Conference on Wireless Technologies, Embedded and Intelligent Systems (WITS), Morocco, 2019: 1-6.
2022, Vol. 37 
