换油对变压器油中糠醛含量和绝缘纸老化评估的影响及修正

doi:10.19595/j.cnki.1000-6753.tces.151796

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (13908 KB)
输出: BibTeX | EndNote (RIS)

摘要为研究现场变压器换油后油中糠醛的变化规律及换油对使用油中糠醛评估绝缘纸老化的影响,在实验室对油纸绝缘样品进行130℃加速热老化,在老化的前、中、后期分别换油,对比换油前、后油中糠醛的含量。结果表明,换油后,油中糠醛大量损失;换油前、后油中糠醛含量的差值随老化时间的加长而逐渐减小;不考虑换油,直接使用油中糠醛评估绝缘纸老化会使评估结果偏高,误差在换油后初期尤其显著。定义在相同的老化时间换油后与换油前油中糠醛的比例为修正函数,研究了修正函数的变化规律,并用其对换油后油中糠醛进行修正。结果表明,使用修正函数可以有效改善换油后绝缘纸老化程度的评估效果。研究了修正函数向现场运行温度推广的方法,以利于现场变压器换油后的糠醛修正。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	林元棣
	廖瑞金
	张镱议
	柳海滨

关键词 ：变压器, 油纸绝缘, 老化评估, 糠醛分析, 换油

Abstract：In order to investigate the changing of furfural content in insulating oil after oil replacement and its effects on insulation paper aging assessment, accelerated thermal aging test of oil-paper insulation samples was conducted at 130℃ in the laboratory. The aged insulating oil was replaced at the early, middle and late aging stages respectively, and the furfural content in oil was compared. The results showed that the furfural content greatly declined after oil replacement. The difference of furfural content in oil before and after oil replacement decreased with aging. If oil replacement was neglected, the aging assessment of paper will cause over-estimation, especially at the early stage after oil replacement. Furfural modification function was defined as the ratio of furfural in oil at the same time point before and after oil replacement. The changing rules of furfural modification function were studied and used to correct the furfural content. It was shown that the modification function could effectively improve the aging assessment results. The furfural modification function was generalized to operation temperature, which can correct the furfural content of in-service transformers.

Key words： Transformer oil-paper insulation aging assessment furfural analysis oil replacement

收稿日期: 2015-10-30 出版日期: 2017-07-19

PACS:

TM855

基金资助:国家创新研究群体基金（51321063）和国家自然科学基金（51277187）资助项目

通讯作者: 林元棣男,1988年生,博士,研究方向为变压器状态评估与寿命预测。E-mail: linyuandiintor@163.com

作者简介: 廖瑞金男,1963年生,教授,博士生导师,研究方向为电气设备绝缘在线监测与故障诊断研究和高电压测试技术。E-mail: rjliao@cqu.edu.cn

引用本文:

林元棣, 廖瑞金, 张镱议, 柳海滨. 换油对变压器油中糠醛含量和绝缘纸老化评估的影响及修正[J]. 电工技术学报, 2017, 32(13): 255-263. Lin Yuandi, Liao Ruijin, Zhang Yiyi, Liu Haibin. Effects and Corrections of Oil Replacement upon Furfural Content in Insulating Oil and Aging Assessment of Insulation Paper of Power Transformers. Transactions of China Electrotechnical Society, 2017, 32(13): 255-263.

链接本文:

https://dgjsxb.ces-transaction.com/CN/10.19595/j.cnki.1000-6753.tces.151796 https://dgjsxb.ces-transaction.com/CN/Y2017/V32/I13/255

[1] 廖瑞金, 王季宇, 袁媛, 等. 换流变压器下新型纤维素绝缘纸特性综述[J]. 电工技术学报, 2016, 31(10): 1-15.
Liao Ruijin, Wang Jiyu, Yuan Yuan, et al. Review on the characteristic of new cellulose insulation paper used in the converter transformer[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 1-15.
[2] 陈伟根, 滕黎, 刘军, 等. 基于遗传优化支持向量机的变压器绕组热点温度预测模型[J]. 电工技术学报, 2014, 29(1): 44-51.
Chen Weigen, Teng Li, Liu Jun, et al. Transformer winding hot-spot temperature prediction model of support vector machine optimized by genetic algo- rithm[J]. Transactions of China Electrotechnical Society, 2014, 29(1): 44-51.
[3] 杨丽君, 徐积全, 胡恩德, 等. 变压器油中腐蚀性硫浓度对绕组绝缘电气性能的影响[J]. 电工技术学报, 2016, 31(10): 42-48.
Yang Lijun, Xu Jiquan, Hu Ende, et al. The influence of corrosive sulfur concentration in transformer oil to the electrical properties of insulated windings[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 42-48.
[4] 杨丽君, 廖瑞金, 孙会刚, 等. 油纸绝缘热老化特性及生成物的对比分析[J]. 中国电机工程学报, 2008, 28(22): 53-58.
Yang Lijun, Liao Ruijin, Sun Huigang, et al. Con- trasting analysis and investigation on properties and products of oil-paper during thermal aging process[J]. Proceedings of the CSEE, 2008, 28(22): 53-58.
[5] 廖瑞金, 冯运, 杨丽君, 等. 油纸绝缘老化特征产物生成速率研究[J]. 中国电机工程学报, 2008, 28(10): 142-147.
Liao Ruijin, Feng Yun, Yang Lijun, et al. Study on generation rate of characteristic products of oil-paper insulation aging[J]. Proceedings of the CSEE, 2008, 28(10): 142-147.
[6] 廖瑞金, 梁帅伟, 周天春, 等. 天然酯-纸绝缘热老化速度减缓及其原因分析[J]. 电工技术学报, 2008, 23(9): 32-37.
Liao Ruijin, Liang Shuaiwei, Zhou Tianchun, et al. Comparison for the mineral oil-paper and the nature ester-paper insulation degradation and cause analysis[J]. Transactions of China Electrotechnical Society, 2008, 23(9): 32-37.
[7] 唐超, 张松, 张福州, 等. 变压器绝缘纸纤维素耐热老化性能提升的模拟及试验[J]. 电工技术学报, 2016, 31(10): 68-76.
Tang Chao, Zhang Song, Zhang Fuzhou, et al. Simulation and experimental about the thermal aging performance improvement of cellulose insulation paper[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 68-76.
[8] 梁帅伟, 廖瑞金, 郝建, 等. 一种抗老化绝缘油对绝缘纸热老化影响及原因分析[J]. 电工技术学报, 2012, 27(5): 21-25.
Liang Shuaiwei, Liao Ruijin, Hao Jian, et al. Effects on oil-immersed paper for an antioxidation insulation oil and cause analysis[J]. Transactions of China Electrotechnical Society, 2012, 27(5): 21-25.
[9] 张镱议, 廖瑞金, 杨丽君, 等. 基于云理论的电力变压器绝缘状态评估方法[J]. 电工技术学报, 2012, 27(5): 13-20.
Zhang Yiyi, Liao Ruijin, Yang Lijun, et al. An assessment method for insulation condition of power transformer based upon cloud model[J]. Transactions of China Electrotechnical Society, 2012, 27(5): 13-20.
[10] Wang M, Vandermaar A J, Srivastava K D. Review of condition assessment of power transformers in service[J]. IEEE Electrical Insulation Magazine, 2002, 18(6): 12-25.
[11] Oommen T V, Prevost T. Cellulose insulation in oil-filled power transformers. Part II: maintaining insulation integrity and life[J]. IEEE Electrical Insulation Magazine, 2006, 22(2): 5-14.
[12] Höhlein I, Kachler A J. Aging of cellulose at transformer service temperatures, part 2: influence of moisture and temperature on degree of poly- merization and formation of furanic compounds in free-breathing systems[J]. IEEE Electrical Insulation Magazine, 2005, 21(5): 20-24.
[13] Cheim L, Platts D, Prevost T, et al. Furan analysis for liquid power transformers[J]. IEEE Electrical Insu- lation Magazine, 2012, 28(2): 8-21.
[14] Emsley A M, Xiao X, Heywood R J, et al. Degradation of cellulosic insulation in power trans- formers, part 2: formation of furan products in insulating oil[J]. IEE Proceedings-Science Measure- ment and Technology, 2000, 147(3): 110-114.
[15] Feng D, Wang Z, Jarman P. Transmission power transformer assessment using furan measurement with the aid of thermal model[C]//IEEE International Conference on Condition Monitoring and Diagnosis, Bali, Indonesia, 2012: 521-524.
[16] Shang Y, Yang L, Guo Z, et al. Assessing aging of large transformers by furfural investigation[C]//IEEE 7th International Conference on Solid Dielectrics, Eindhoven, Netherlands, 2001: 272-274.
[17] MacAlpine J M K, 张潮海. 糠醛浓度判断变压器绝缘纸寿命的综述[J]. 高电压技术, 2001, 27(4): 63-67.
MacAlpine J M K, Zhang Chaohai. Study on the paper ageing in transformer oil using furfural concentration[J]. High Voltage Engineering, 2001, 27(4): 63-67.
[18] MacAlpine J M K, 张潮海. 糠醛浓度判断变压器绝缘纸寿命的现场测量[J]. 高电压技术, 2001, 27(6): 46-50.
MacAlpine J M K, Zhang Chaohai. Study on the paper ageing in transformer oil using furfural con- centration as indication[J]. High Voltage Engineering, 2001, 27(6): 46-50.
[19] Lewand L R. Practical experience gained from furanic compound analysis[C]//The Seventy-Third Annual International Doble Client Conference, MA, USA, 2006.
[20] Lelekakis N, Guo W, Martin D, et al. A field study of aging in paper-oil insulation systems[J]. IEEE Electrical Insulation Magazine, 2012, 28(1): 12-19.
[21] Liao R, Lin Y, Guo P, et al. The Effects of insulating oil replacement upon power transformer condition assessment[J]. Electric Power Components and Systems, 2015, 43(17): 1971-1979.
[22] Lundgaard L E, Hansen W, Linhjell D, et al. Aging of oil-impregnated paper in power transformers[J]. IEEE Transactions on Power Delivery, 2004, 19(1): 230-239.
[23] Emsley A M, Stevens G C. Review of chemical indicators of degradation of cellulosic electrical paper insulation in oil-filled transformers[J]. IEE Proceedings-Science Measurement and Technology, 1994, 141(5): 324-334.