定子电流二次方法的异步电机转子复合故障诊断

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (496 KB)
输出: BibTeX | EndNote (RIS)

摘要

为了突出故障早期的故障特征信息,避免复杂算法,实现故障早期状态在线监测,提出定子电流二次方法（流方）的笼型异步电机转子复合故障检测。定子电流经过二次方后转移和放大了定子电流中的故障信号,由于转子断条和气隙偏心的故障特征频率在频谱分布上的差距,转子复合故障得到分离和辨识。同时比较了单相流方和三相总流方对复合故障的诊断效果。复合故障时,流方的故障频率不是单一故障频率的直接累加,还包括两故障频率所引起的交叉干扰项。实验表明,随着断条数的增加,复合故障中表征断条的故障特征分量的幅值增加,有利于故障程度的量化和诊断系统的建立。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	王臻
	李承
	林志芳
	许允之
	陈旭

关键词 ：定子电流二次方, 转子复合故障, 故障特征频率, 在线监测, 交叉干扰

Abstract：

In order to highlight the fault characteristic components and avoid complex algorithms, on-line monitoring of squirrel cage asynchronous motor initial fault is achieved. Rotor composite faults diagnosis of motor based on the square calculation of stator current is proposed. The fault signal of the stator current is transferred and amplified because of the squared stator current. The fault characteristic frequency components of broken bar and rotor eccentricity are different in spectrum distribution, so the rotor composite fault is separated and identified. At the same time, the diagnosis effects of one-phase squared current are different from those of three-phase squared current. The composite faults frequency is not the sum of two single fault directly, but takes into account the cross interference caused by two kinds of fault frequency. Experiments indicate that the amplitude of 2sf₁ for the rotor composite fault increases with increasing broken bar, which is beneficial to the quantification of the fault extent and establishment of diagnostic rules.

Key words： Squared calculation of stator current the rotor composite fault the characteristic fault frequency online monitoring cross interference

收稿日期: 2014-07-14 出版日期: 2016-09-01

PACS:

TM307

基金资助:

湖北省自然科学基金资助项目（2012FFB02201）

作者简介: 王臻男,1989年生,硕士研究生,主要从事电机故障诊断、电力系统稳定与控制的研究。E-mail: 13813488534@163.com;李承男,1957年生,博士,教授,主要从事电力谐波治理、单周控制理论及应用和神经网络应用等方面的研究。E-mail: ll_cheng@tom.com（通信作者）

引用本文:

王臻, 李承, 林志芳, 许允之, 陈旭. 定子电流二次方法的异步电机转子复合故障诊断[J]. 电工技术学报, 2016, 31(16): 50-56. Wang Zhen, Li Cheng, Lin Zhifang, Xu Yunzhi, Chen Xu. Rotor Composite Fault Diagnosis in Asynchronous Motor Using the Square Calculation of Stator Current. Transactions of China Electrotechnical Society, 2016, 31(16): 50-56.

链接本文:

https://dgjsxb.ces-transaction.com/CN/Y2016/V31/I16/50

[1] 赵妍, 李志民, 李天云. 一种基于谱峭度的异步电机故障诊断方法[J]. 电工技术学报, 2014, 29(5): 189-196.
Zhao Yan, Li Zhimin, Li Tianyun. A method for fault diagnosis of induction motors based on spectral kurtosis[J]. Transactions of China Electrotechnical Society, 2014, 29(5): 189-196.
[2] 孙丽玲, 许伯强, 李志远. 基于MUSIC与SAA的笼型异步电动机转子断条故障检测[J]. 电工技术学报, 2012, 27(12): 205-212.
Sun Liling, Xu Boqiang, Li Zhiyuan. A MUSIC- SAA-based detection method for broken rotor bar fault in induction motors[J]. Transactions of China Electrotechnical Society, 2012, 27(12): 205-212.
[3] Xu B Q, Chu Y L, Sun L L, et al. On-line methods to detect broken rotor bars in squirrel cage asynchronous motors[C]//Proceedings of International Conference on Electrical Machines and Systems, Seoul, Korea, 2007: 1107-1111.
[4] Cruz S M A, Cardoso A J M. Stator winding fault diagnosis in three-phase synchronous and asynchronous motors by the extend Park’s vector approach[J]. IEEE Transactions on Industry Applications, 2001, 37(5): 1227-1233.
[5] Park Y S, Jang S M, Choi J Y, et al. Fault detection of squirrel cage induction motor by analyzing motor current signals[C]//IEEE Vehicle Power and Pro- pulsion Conferenc, Seoul, Korea, 2012: 219-222.
[6] Ben Salem S, Bacha K, Gossa M. Induction motor fault diagnosis using an improved combination of Hilbert and park transforms[C]//IEEE Electro- technical Conference, Yasmine, Hammamet, 2012: 1141-1146.
[7] Drif M, Cardoso A J M. Airgap eccentricity fault diagnosis, in three-phase induction motors, using the instantaneous power factor signature analysis[C]// IET Conference on Power Electronics, Machines and Drives, York, 2008: 587-591.
[8] 刘振兴, 尹项根, 张哲, 等. 基于瞬时功率信号频谱分析的鼠笼式异步电动机转子故障在线诊断方法[J]. 中国电机工程学报, 2003, 23(10): 148-152.
Liu Zhenxing, Yin Xianggen, Zhang Zhe, et al. On-line rotor fault diagnosis way based on spectrum analysis of instantaneous power in squirrel cage induction motors[J]. Proceedings of the CSEE, 2003, 23(10): 148-152.
[9] 侯新国, 吴正国, 夏立, 等. 瞬时功率分解算法在感应电机定子故障诊断中的应用[J]. 中国电机工程学报, 2005, 25(5): 110-115.
Hou Xinguo, Wu Zhengguo, Xia Li, et al. App- lication of instantaneous power decomposition tech- nique in induction, motors’ stator fault diagnosis[J]. Proceedings of the CSEE, 2005, 25(5): 110-115.
[10] Drif M, Cardoso A J M. The instantaneous power factor approach for rotor cage faults diagnosis in three-phase induction motors[C]//International Sympo- sium on Power Electronics, Electrical Drives, Auto- mation and Motion, Ischia, 2008: 173-178.
[11] 杨伟, 顾明星, 彭静萍. 证据理论在电机故障诊断中的应用[J]. 电力系统保护与控制, 2010, 38(2): 64-67.
Yang Wei, Gu Mingxing, Peng Jingping. Application of evidence theory in fault diagnosis for electric machine[J]. Power System Protection and Control, 2010, 38(2): 64-67.
[12] 张雄希, 刘振兴. 基于倒频谱分析的电机故障检测[J]. 电力系统保护与控制, 2010, 38(20): 145-147.
Zhang Xiongxi, Liu Zhenxing. Fault detection for motor based on spectrum analysis[J]. Power System Protection and Control, 2010, 38 (20): 145-147.
[13] 王臻, 李承, 王蕾. 基于流方的笼型异步电机转子故障诊断[J]. 电机与控制应用, 2014, 41(7): 43-48.
Wang Zhen, Li Cheng, Wang Lei. Rotor fault diagnosis of squirrel cage asynchronous motor based on stator current’s square[J]. Electric Machine and Control Application, 2014, 41(7): 43-48.
[14] 孙丽玲, 王续, 许伯强. 基于SVD滤波技术与快速四阶累积量ESPRIT算法的异步电动机转子断条故障检测新方法[J]. 电工技术学报, 2015, 30(10): 147-156.
Sun Liling, Wang Xu, Xu Boqiang. A detection method for broken rotor bar fault in induction motors based on SVD and SFOC-ESPRIT[J]. Transactions of China Electrotechnical Society, 2015, 30(10): 147- 156.
[15] 鲍晓华, 吕强. 感应电机气隙偏心故障研究综述及展望[J]. 中国电机工程学报, 2013, 33(6): 93-98.
Bao Xiaohua, Lü Qiang. Review and prospect of air-gap eccentricity faults in induction machines[J]. Proceedings of the CSEE, 2013, 33(6): 93-98.
[16] 刘振兴, 尉宇, 赵敏, 等. 基于RELAX频谱分析方法的鼠笼式异步电动机转子故障诊断[J]. 中国电机工程学报, 2006, 26(22): 146-150.
Liu Zhenxing, Wei Yu, Zhao Min, et al. Fault diagnosis way based on RELAX spectrum analysis in squirrel cage induction motors[J]. Proceedings of the CSEE, 2006, 26(22): 146-150.
[17] 王臻, 李承, 张舜钦, 等. 基于改进矩阵束滤波与检测的异步电动机故障诊断新方法[J]. 电工技术学报, 2015, 30(12): 213-219.
Wang Zhen, Li Cheng, Zhang Shunqin, et al. A new filter and detection approach of fault in asynchronous motor based on improved matrix pencil[J]. Transa- ctions of China Electrotechnical Society, 2015, 30(12): 213-219.
[18] 史丽萍, 王攀攀, 胡泳军, 等. 基于骨干微粒群算法和支持向量机的电机转子断条故障诊断[J]. 电工技术学报, 2014, 29(1): 147-155.
Shi Liping, Wang Panpan, Hu Yongjun, et al. Broken rotor bar fault diagnosis of induction motors based on bare-bone particle swarm optimization and support vector machine[J]. Transactions of China Electro- technical Society, 2014, 29(1): 147-155.