Rotating High Frequency Signal Injection Based on Interior Permanent Magnet Synchronous Motor Rotor Position Estimation with the Demodulation Implemented on the Synchronous Reference Frame
Liu Shanhong, Yang Shuying, Li Haoyuan, Liu Shiyuan, Zhang Xing
School of Electrical Engineering and Automation Hefei University of Technology Hefei 230009 China
Abstract：Rotating high-frequency(HF) injection technique is a typical scheme for position estimation of interior permanent magnet synchronous motor(IPMSM) in standstill and low speeds. It has good stability, but its estimation accuracy is affected by the digital control delay and the demodulation filtering delay, resulting in a limited accuracy of the estimated position. To compensate the estimation error, a synchronous reference frame(SRF) based demodulation scheme is proposed in this paper. Both the extraction of the HF carrier currents and the demodulation of the rotor position are implemented in the estimated SRF. By the phase relationship of the positive- and negative-sequence HF currents, the delay error is compensated inherently, and the estimation accuracy is enhanced. In the proposed estimation scheme, the HF rotating voltage is still injected in the stationary reference frame, but the extraction and demodulation processes are based on the estimated SRF. In this SRF, the positive- and the negative-sequence components has the same frequency, therefore, the delaying effects cause the same phase delay to both sequence components, which is the basis to compensate the phase delay of the negative-sequence current with the positive-sequence current. With the compensation, the position accuracy is consequently improved. Effectiveness of this scheme is verified through the experimental results on an 18kW IPMSM test rig.
刘善宏, 杨淑英, 李浩源, 刘世园, 张兴. 基于旋转坐标系解调的内置式永磁同步电机旋转高频注入法位置观测[J]. 电工技术学报, 2020, 35(4): 708-716.
Liu Shanhong, Yang Shuying, Li Haoyuan, Liu Shiyuan, Zhang Xing. Rotating High Frequency Signal Injection Based on Interior Permanent Magnet Synchronous Motor Rotor Position Estimation with the Demodulation Implemented on the Synchronous Reference Frame. Transactions of China Electrotechnical Society, 2020, 35(4): 708-716.
[1] Li Haoyuan, Zhang Xing, Yang Shuying, et al.Analysis and design of IPMSM drive system based on visualization technique in discrete time domain[C]// IEEE Energy Conversion Congress and Exposition, Cincinnati, USA, 2017: 1940-1946. [2] 章金晶, 汤宁平. 永磁同步电动机电感参数测量的研究综述[J]. 电气技术, 2018, 19(2): 1-5. Zhang Jinjing, Tang Ningping.The review of inductance parameters of measurement permanent magnet synchronous motor[J]. Electrical Engineering, 2018, 19(2): 1-5. [3] Dutta R, Rahman M F.Design and analysis of an interior permanent magnet(IPM) machine with very wide constant power operation range[J]. IEEE Transactions on Energy Conversion, 2008, 23(1): 25-33. [4] 王高林, 李卓敏, 詹瀚林, 等. 考虑逆变器非线性的内置式永磁同步电机转子位置锁相环观测器[J]. 电工技术学报, 2014, 29(3): 172-179. Wang Gaolin, Li Zhuomin, Zhan Hanlin, et al.Phase- locked-loop rotor position observer for IPMSM considering inverter nonlinearity[J]. Transactions of China Electrotechnical Society, 2014, 29(3): 172-179. [5] Song Xinda, Fang Jiancheng, Han Bancheng, et al.Adaptive compensation method for high-speed surface PMSM sensorless drives of EMF-based position estimation error[J]. IEEE Transactions on Power Electronics, 2016, 31(2): 1438-1449. [6] 王要强, 冯玉涛, 秦明, 等. 表贴式永磁同步电机全阶滑模观测与控制策略[J]. 电工技术学报, 2018, 33(24): 1-12. Wang Yaoqiang, Feng Yutao, Qin Ming, et al.Full- order sliding mode observation and control strategy for surface permanent magnet synchronous motor[J]. Transactions of China Electrotechnical Society, 2018, 33(24): 1-12. [7] 刘计龙, 肖飞, 麦志勤, 等. IF控制结合滑模观测器的永磁同步电机无位置传感器复合控制策略[J]. 电工技术学报, 2018, 33(4): 919-929. Liu Jilong, Xiao Fei, Mai Zhiqin, et al.Hybrid position-sensorless control scheme for PMSM based on combination of if control and sliding mode observer[J]. Transactions of China Electrotechnical Society, 2018, 33(4): 919-929. [8] 田素立, 赵瑞杰, 李朝锋, 等. 永磁同步电机角度软锁相环估算方法研究[J]. 电力系统保护与控制, 2017, 45(18): 108-113. Tian Suli, Zhao Ruijie, Li Chaofeng, et al.Research of angle soft phase-locked loop estimation method of permanent magnet synchronous motor[J]. Power System Protection and Control, 2017, 45(18): 108-113. [9] 黄科元, 周李泽, 周滔滔, 等. 一种增强可靠性的永磁同步电机初始角检测[J]. 电工技术学报, 2015, 30(1): 45-51. Huang Keyuan, Zhou Lize, Zhou Taotao, et al.An enhanced reliability method for initial angle detection on surface mounted permanent magnet synchronous motors[J]. Transactions of China Electrotechnical Society, 2015, 30(1): 45-51. [10] 尹忠刚, 张彦平, 张延庆, 等. 采用免疫高频脉动信号注入的PMSM转速辩识方法[J]. 电工技术学报, 2016, 31(增刊2): 243-254. Yin Zhonggang, Zhang Yanping, Zhang Yanqing, et al.High frequency pulsating signal injection for permanent magnet synchronous machines based on immune algorithm[J]. Transactions of China Electro- technical Society, 2016, 31(S2): 243-254. [11] 田兵, 安群涛, 孙东阳, 等. 基于磁饱和效应的表贴式永磁同步电机初始位置检测方法[J]. 电工技术学报, 2016, 31(1): 155-164. Tian Bing, An Quntao, Sun Dongyang, et al.Initial position estimation for surface permanent magnet synchronous motors based on magnetic saturation effect[J]. Transactions of China Electrotechnical Society, 2016, 31(1): 155-164. [12] Liu J M, Zhu Z Q.Novel sensorless control strategy with injection of high-frequency pulsating carrier signal into stationary reference frame[J]. IEEE Transactions on Industry Applications, 2014, 50(4): 2574-2583. [13] Luo Xin, Tang Qipeng, Shen Anwen, et al.PMSM sensorless control by injecting HF pulsating carrier signal into estimate fixed-frequency rotating reference frame[J]. IEEE Transactions on Industrial Electronics, 2016, 63(4): 2294-2303. [14] Wang Gaolin, Yang Lei, Zhang Guoqiang, et al.Comparative investigation of pseudorandom high- frequency signal injection schemes for sensorless IPMSM drives[J]. IEEE Transactions on Power Electronics, 2017, 32(3): 2123-2132. [15] Liu J M, Zhu Z Q.Sensorless control strategy by square-waveform high-frequency pulsating signal injection into stationary reference frame[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2014, 2(2): 171-180. [16] 张国强, 王高林, 徐殿国. 基于无滤波器方波信号注入的永磁同步电机初始位置检测方法[J]. 电工技术学报, 2017, 32(13): 162-168. Zhang Guoqiang, Wang Gaolin, Xu Dianguo.Filterless square-wave injection based initial position detection for permanent magnet synchronous machines[J]. Transactions of China Electrotechnical Society, 2017, 32(13): 162-168. [17] Liu Jinbo, Nondahl T, Schmidt P, et al.An on-line position error compensation method for sensorless IPM motor drives using high frequency injection[C]// 2009 IEEE Energy Conversion Congress and Exposition, San Jose, USA, 2009: 1946-1953. [18] 李浩源, 张兴, 杨淑英, 等. 基于旋转高频注入的内置式永磁同步电机初始位置检测算法[J]. 电工技术学报, 2018, 33(8): 1723-1731. Li Haoyuan, Zhang Xing, Yang Shuying, et al.A detecting algorithm for initial position of interior permanent magnet synchronous motor based on rotating high frequency injection[J]. Transactions of China Electrotechnical Society, 2018, 33(8): 1723-1731. [19] 刘景林, 鲁家栋. 基于相电流正负序分量相角差的高精度内置式永磁同步电机转子初始位置检测方案[J]. 电工技术学报, 2016, 31(23): 63-69. Liu Jinglin, Lu Jiadong.High-precision estimation method of initial rotor position for IPMSM based on phase difference of positive an negative sequence current component[J]. Transactions of China Electro- technical Society, 2016, 31(23): 63-69. [20] Kim S I, Im J H, Song E Y, et al.A new rotor position estimation method of IPMSM using all-pass filter on high-frequency rotating voltage signal injection[J]. IEEE Transactions on Industrial Elec- tronics, 2016, 63(10): 6499-6509. [21] 杨健, 杨淑英, 李浩源, 等. 基于旋转高频电压注入的永磁同步电机转子初始位置辩识方法[J]. 电工技术学报, 2018, 33(15): 3547-3555. Yang Jian, Yang Shuying, Li Haoyuan, et al. Initial rotor position estimation for IPMSM based on high frequency rotating voltage injection[J]. Transactions of China Electrotechhnial Society, 2018, 33(15): 3547-3555. [22] Holmes D G, Lipo T A, Mcgrath B P, et al.Optimized design of stationary frame three phase AC current regulators[J]. IEEE Transactions on Power Electronics, 2009, 24(11): 2417-2426.
2020, Vol. 35 
